 |
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
| Datasheet File OCR Text: |
| PM75CBS060 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 IntellimodTM Module MAXISS SeriesTM Multi AXIS Servo IPM 75 Amperes/600 Volts D H F G 1 4 A E G G 7 10 15 Y AA M N P TERMINAL CODE 1. VWPC 2. WP 3. VWP1 4. VVPC 5. VP 6. VP1 7. VUPC 8. UP 9. VUP1 10. VNC BJ K W L (11 TYP.) V U N P Q R U CV LABEL X FO VNC WN VN1 VN UN VWPC WP Z S S W T AC AB 11. VN1 12. WN 13. V N 14. UN 15. FO S S T VWP1 VVPC VP VVP1 VUPC UP VUP1 Rfo GND IN VCC GND IN VCC GND IN VCC GND IN VCC GND IN VCC GND IN VCC Description: Powerex IntellimodTM Intelligent Power Modules are isolated base modules designed for power switching applications operating at frequencies to 20kHz. Built-in control circuits provide optimum gate drive and protection for the IGBT and free-wheel diode power devices. Features: Complete Output Power Circuit Gate Drive Circuit Protection Logic - Short Circuit - Over Current - Under Voltage - Over Temperature by On-Chip Temperature Sensor Low Loss Using 4th Generation IGBT Chip Applications: Motion Control Servo Control Ordering Information: Example: Select the complete part number from the table below -i.e. PM100CBS060 is a 600V, 100 Ampere IntellimodTM Intelligent Power Module. Type PM Current Rating Amperes 75 VCES Volts (x 10) 060 SI GND OUT OT SI GND OUT OT SI GND OUT OT SI GND OUT OT SI GND OUT OT SI GND OUT OT N Rfo = 1.5K OHM W V U P Outline Drawing and Circuit Diagram Dimensions A B C D E F G H J K L M N P Inches 4.72 1.97 1.18 0.3 4.170.1 0.94 0.40 0.34 1.54 0.10 0.10 0.98 5.5 Dia. 0.28 Rad. Millimeters 120.0 50.0 30.0 7.0 106.00.3 23.79 10.16 8.5 39.0 2.5 2.54 25.0 Dia 5.5 Rad. 7.0 Dimensions Q R S T U V W X Y Z AA AB AC Inches 0.12 0.59 0.75 0.39 0.24 1.10 0.08 0.26 0.43 0.04 0.03 0.20 0.35 Millimeters 3.0 15.0 19.0 10.0 6.0 28.0 2.0 6.5 11.0 1.0 0.64 5.0 9.0 1 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM75CBS060 IntellimodTM Module MAXISS SeriesTM, Multi AXIS Servo IPM 75 Amperes/600 Volts Absolute Maximum Ratings, Tj = 25C unless otherwise specified Characteristics Storage Temperature Case Operating Temperature* Mounting Torque, M5 Mounting Screws Mounting Torque, M5 Main Terminal Screws Module Weight (Typical) Supply Voltage Protected by OC and SC (VD = 13.5 - 16.5V, Inverter Part, Tj = 125C) Supply Voltage, Surge (Applied between P - N) Isolation Voltage, AC 1 minute, 60Hz Sinusoidal Symbol Tstg TC -- -- -- VCC(prot.) VCC(surge) VISO PM75CBS060 -40 to 125 -20 to 100 31 31 400 400 500 2500 Units C C in-lb in-lb Grams Volts Volts Vrms IGBT Inverter Sector Collector-Emitter Voltage (VD = 15V, VCIN = 15V) Collector Current, (TC = 25C) Peak Collector Current, (TC = 25C) Collector Dissipation Power Device Junction Temperature VCES IC ICP PC Tj 600 75 150 462 -20 to 150 Volts Amperes Amperes Watts C Control Sector Supply Voltage Applied between (VUP1-VUPC, VVP1-VVPC, VWP1-VWPC, VN1-VNC) Input Voltage Applied between (UP-VUPC, VP-VVPC, WP-VWPC, UN- VN- WN-VNC) Fault Output Supply Voltage (Applied between FO and VNC) Fault Output Current (Sink Current at FO Terminal) VD VCIN VFO IFO 20 20 VD +0.5 20 Volts Volts Volts mA *TC Measure Point (Under the Chip) BOTTOM VIEW Y X -Y P N U V W (mm) ARM AXIS X Y UP IGBT 83.3 3.8 FWDi 83.3 -4.3 IGBT 41.8 3.8 VP FWDi 41.8 -4.3 16.8 3.8 WP IGBT FWDi 16.8 -4.3 70.8 -2.3 UN IGBT FWDi 70.8 -10.3 54.3 -2.3 VN IGBT FWDi 54.3 -10.3 29.3 -2.3 WN IGBT FWDi 29.3 -10.3 2 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM75CBS060 IntellimodTM Module MAXISS SeriesTM, Multi AXIS Servo IPM 75 Amperes/600 Volts Electrical and Mechanical Characteristics, Tj = 25C unless otherwise specified Characteristics Symbol Test Conditions Min. Typ. Max. Units IGBT Inverter Sector Collector-Emitter Cutoff Current ICES VEC VCE(sat) VCE = VCES, VD = 15V, Tj = 25C VCE = VCES, VD = 15V, Tj = 125C Diode Forward Voltage Collector-Emitter Saturation Voltage -IC = 75A, VD = 15V, VCIN = 15V VD = 15V, VCIN = 0V, IC = 75A, Tj = 25C VD = 15V, VCIN = 0V, IC = 75A, Tj = 125C Inductive Load Switching Times ton trr tC(on) toff tC(off) VD = 15V, VCIN = 0 ~ 15V, VCC = 300V, IC = 75A, Tj = 125C, Inductive Load 0.8 -- -- -- -- 1.2 0.15 0.4 2.4 0.5 2.4 0.3 1.0 3.3 1.0 S S S S S -- 1.7 2.3 Volts -- -- -- -- -- -- 2.2 1.7 1.0 10 3.3 2.3 mA mA Volts Volts Control Sector Over Current Trip Level OC Tj = -20C, VD = 15V Tj = 25C, VD = 15V Tj = 125C, VD = 15V Short Circuit Trip Level Over Current Delay Time Over Temperature Protection (Detect Tj of IGBT Chip) Supply Circuit Under Voltage Protection (-20 Tj 125C) Circuit Current SC toff(OC) OT OTR UV UVR ID Vth(on) Vth(off) IFO(H) IFO(L) Minimum Fault Output Pulse Width tFO -20C Tj 125C, VD = 15V VD = 15V Trip Level Reset Level Trip Level Reset Level VD = 15V, VCIN = 15V, VN1-VNC VD = 15V, VCIN = 15V, VXP1-VXPC Input ON Threshold Voltage Input OFF Threshold Voltage Fault Output Current Applied between UP-VUPC, VP-VVPC, WP-VWPC, UN, VN, WN-VNC VD = 15V, VFO = 15V VD = 15V, VFO = 15V VD = 15V -- 145 115 -- -- 135 -- 11.5 -- -- -- 1.2 1.7 -- -- 1.0 -- 198 -- 241 10 145 125 12.0 12.5 40 13 1.5 2.0 -- 10 1.8 330 270 -- -- -- 155 -- 12.5 -- 60 18 1.8 2.3 0.01 15 -- Amperes Amperes Amperes Amperes S C C Volts Volts mA mA Volts Volts mA mA mS 3 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM75CBS060 IntellimodTM Module MAXISS SeriesTM, Multi AXIS Servo IPM 75 Amperes/600 Volts Thermal Characteristics Characteristic Junction to Case Thermal Resistance Symbol Rth(j-c)Q Rth(j-c)F Contact Thermal Resistance Rth(c-f) Condition Each IGBT* Each FWDi* Case to Fin Per Module, Thermal Grease Applied *TC measured point is just under the chips. **If you use this value, Rth(f-a) should be mesured just under the chips. Min. -- -- -- Typ. -- -- -- Max. 0.27** 0.47** 0.046 Units C/Watt C/Watt C/Watt Recommended Conditions for Use Characteristic Supply Voltage Control Supply Voltage*** Symbol VCC VD VCIN(on) VCIN(off) fPWM tDEAD Condition Applied across P-N Terminals Applied between VUP1-VUPC, VVP1-VVPC, VWP1-VWPC, VN1-VNC Input ON Voltage Input OFF Voltage PWM Input Frequency Minimum Dead Time Applied between UP-VUPC, VP-VVPC, WP-VWPC, UN, VN, WN-VNC Using Application Circuit Input Signal 0.8 4.0 20 2.5 Volts Volts kHz S Value 400 15 1.5 Units Volts Volts ***With ripple satisfying the following conditions: dv/dt 5v/s, Variation 2V peak to peak. 4 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM75CBS060 IntellimodTM Module MAXISS SeriesTM, Multi AXIS Servo IPM 75 Amperes/600 Volts COLLECTOR-EMITTER SATURATON VOLTAGE CHARACTERISTICS (TYPICAL) COLLECTOR-EMITTER SATURATION VOLTAGE, VCE(SAT), (VOLTS) SATURATION VOLTAGE CHARACTERISTICS (TYPICAL) COLLECTOR-EMITTER VOLTAGE, VCE(SAT), (VOLTS) OUTPUT CHARACTERISTICS (TYPICAL) 2.0 2.0 COLLECTOR CURRENT, IC, (AMPERES) 100 Tj = 25oC 15 13 1.5 1.5 80 60 40 VD = 17V 1.0 1.0 0.5 VD = 15V Tj = 25C Tj = 125C 0.5 IC = 75A Tj = 25C Tj = 125C 20 0 0 20 40 60 80 100 COLLECTOR CURRENT, IC, (AMPERES) 0 12 13 14 15 16 17 18 CONTROL SUPPLY VOLTAGE, VD, (VOLTS) 0 0 0.5 1.0 1.5 2.0 COLLECTOR-EMITTER VOLTAGE, VCE(sat), (VOLTS) SWITCHING TIME VS. COLLECTOR CURRENT (TYPICAL) SWITCHING TIME VS. COLLECTOR CURRENT (TYPICAL) SWITCHING ENERGY, ESW(on), ESW(off), (mJ/PULSE) SWITCHING LOSS CHARACTERISTICS (TYPICAL) 101 SWITCHING TIMES, tc(on), tc(off), (s) 101 VCC = 300V VD = 15V Tj = 25C Tj = 125C 101 VCC = 300V VD = 15V Tj = 25C Tj = 125C INDUCTIVE LOAD ESW(off) SWITCHING TIMES, ton, toff, (s) toff 100 ton 100 t(c)off 100 ESW(on) VCC = 300V VD = 15V Tj = 25C Tj = 125C t(c)on 10-1 100 101 COLLECTOR CURRENT, IC, (AMPERES) 102 10-1 100 101 COLLECTOR CURRENT, IC, (AMPERES) 102 10-1 100 101 COLLECTOR CURRENT, IC, (AMPERES) 102 REVERSE RECOVERY CURRENT VS. COLLECTOR CURRENT (TYPICAL) DIODE FORWARD CURRENT, -IC, (AMPERES) DIODE FORWARD CHARACTERISTICS REVERSE RECOVERY CURRENT, Irr, (AMPERES) CIRCUIT CURRENT VS. CARRIER FREQUENCY 100 REVERSE RECOVERY TIME, trr, (S) VCC = 300V VD = 15V Tj = 25C Tj = 125C INDUCTIVE LOAD 102 102 VD = 15V CIRCUIT CURRENT, ID, (mA) 100 VD = 15V Tj = 25C Tj = 125C Irr 80 Tj = 25C 60 N-SIDE 10-1 trr 101 101 40 20 P-SIDE 10-2 100 101 COLLECTOR CURRENT, -IC, (AMPERES) 100 102 100 0 0.5 1.0 1.5 2.0 2.5 DIODE FORWARD VOLTAGE, VEC, (VOLTS) 0 0 5 10 15 20 25 CARRIER FREQUENCY, fC, (kHz) 5 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM75CBS060 IntellimodTM Module MAXISS SeriesTM, Multi AXIS Servo IPM 75 Amperes/600 Volts OVER CURRENT TRIP LEVEL VS. SUPPLY VOLTAGE (TYPICAL) OVER CURRENT TRIP LEVEL, OC, (VD = 15V) = 1.0 OVER CURRENT TRIP LEVEL TEMPERATURE DEPENDENCY (TYPICAL) OVER CURRENT TRIP LEVEL, OC, (Tj = 25C) = 1.0 FAULT OUTPUT PULSE WIDTH VS. TEMPERATURE (TYPICAL) 1.2 Tj = 25C 1.2 FAULT OUTPUT PULSE WIDTH TRIP LEVEL, tFO, (RATIO) 1.2 1.0 0.8 0.6 0.4 0.2 VD = 15V 1.0 0.8 0.6 0.4 0.2 0 12 13 14 15 16 17 18 CONTROL SUPPLY VOLTAGE, VD, (VOLTS) 1.0 0.8 0.6 0.4 0.2 VD = 15V 0 -20 0 20 40 60 80 100 120 140 0 -40 -20 0 20 40 60 80 100 120 140 JUNCTION TEMPERATURE, Tj, (C) JUNCTION TEMPERATURE, Tj, (C) CONTROL SUPPLY VOLTAGE TRIP-RESET LEVEL TEMPERATURE DEPENDENCY (TYPICAL) SUPPLY CIRCUIT UNDER VOLTAGE PROTECTION, TRIP RESET LEVEL, UVt, UVr, (VOLTS) 14 12 10 8 6 4 VD = 15V 2 0 -40 -20 UVt UVr 0 20 40 60 80 100 120 140 JUNCTION TEMPERATURE, Tj, (C) 6 |
Price & Availability of PM75CBS060
 |
|
|
|
|
All Rights Reserved © IC-ON-LINE 2003 - 2022 |
| [Add Bookmark] [Contact Us] [Link exchange] [Privacy policy] |
|
Mirror Sites : [www.datasheet.hk]
[www.maxim4u.com] [www.ic-on-line.cn]
[www.ic-on-line.com] [www.ic-on-line.net]
[www.alldatasheet.com.cn]
[www.gdcy.com]
[www.gdcy.net] |