TFS125H.doc v e rsion 1.2 18.06.2003 vi telefilter filter specification tfs 125 h 1/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m measurement condition ambient temperature: 23 c input pow er level: 0 dbm source impedance: 50 ? single ended load impedance: 50 ? single ended terminating impedances: *) input: 1,03 k ? // -15,4 pf output: 0,88 k ? // -14,8 pf ch aracteristics remark: reference lev e l for the relativ e attenuation a rel of the tfs 125h is the minimum of the pass band a ttenuation. refer ence for the echo response attenuation is the main time respons e lobe, the reference time is defined as t 0 . the nominal frequency f n is fix ed at 125 mhz w i thout tolerance. the giv en v a lues for the relativ e attenuation a rel and for the group delay ripple hav e to be reached at the frequencies giv en below ev en if the centre frequency f c is shifted due to the temper ature coefficient of frequency tc f in the operating temperature range and due to a production tolerance for the centre frequency f c . d a t a ty p. value limit a b solute attenuation w i thin pb 8 db 7... 10 db nominal frequency f n - 125 mhz pass band (pb) - f n 0,6 mhz 1 db bandw idth 1,6 mhz min. 1,2 mhz relativ e attenuation a rel f n ... f n 0,1 mhz - max. 0,4 db f n 0,1 mhz ... f n 0,4 mhz - max. 0,7 db f n 0,4 mhz ... f n 0,6 mhz - max. 1,85 db f n 1,2 mhz ... f n 1,8 mhz 7 db min. 6 db f n 1,8 mhz ... f n 6 mhz 22 db min. 15 db f n 6 mhz ... f n 13 mhz 45 db min. 40 db f n - 13 mhz ... f n - 115 mhz 65 db min. 50 db f n + 13 mhz ... f n + 325 mhz 70 db min. 50 db echo response attenuation a rel t 0 + 2 s 37 db min. 30 db t 0 + 3 s 46 db min. 40 db t 0 + 4 s 56 db min. 50 db t 0 + 5 s 65 db min. 55 db t 0 + 6 s 78 db min. 60 db group delay at f n 700 ns max. 800 ns group delay ripple w i thin pb 50 ns max. 150 ns input pow er lev e l - max. + 10 dbm vswr w i thin pb 14 db min. 2 : 1 intermodulation products ** 70 dbm min. 60 dbm operating temperature range - - 10 c ... + 85 c storage temperature range - - 40 c ... + 125 c temperature coefficient of frequency tc f *** -0,04 ppm/k 2 - frequency inv e rsion temperature t 0 20 c - *) the terminating impedances depend on parasitics and q-v a lues of matching elem ents and the board used, and are to be understood as reference v a lues only . should there be additional questions, do not hesitate to ask fo r an application not e or contact our design team. **) f in,1 =125mhz; f in,2 =125,1mhz; p in =4dbm+loss at f n ; f out,1 =124,9mhz; f out,2 =125,2mhz; then p out <-56dbm ***) ? f(h z ) = t c f (ppm/k2) x (t-t 0 )2 x f to (mhz) ge ne ra te d: ch ecked / ap p r o v ed : vi telefilter reserv es the right to make changes to the product(s) and/ or information contained herei n w i thout notice. no liab ility is assumed as a result of their use or app lication. no rights under any patent accompany t he sale of any such product(s) or information.
TFS125H.doc v e rsion 1.2 18.06.2003 vi telefilter filter specification tfs 125 h 2/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m cons truc tion a nd pin c onfigura t ion (all dimensions in mm) 9,3 ma x . 5, 0 m ax . 1 2 3 4 5 6 7 8 9 10 1, 8 max . 7,1 2,54 0,1 0,10 0,8 2,8 2,54 0,1 2,54 0,1 6 0 1 2 3 4 5 6 7 8 9 10 t f s 125h r25 dat e co de 1 ground 2 ground 3 ground 4 output 5 ground 6 ground 7 ground 8 ground 9 ground 10 input date code: y ear + w eek n 2001 p 2002 r 2003 .... .... ma tc hing c i rc uit: l2 o u t put 50 o h m c2 in p u t 50 o h m c1 l1 sa w 1, 2 , 3, 5, 6, 7 , 8 , 9 10 4 vi telefilter reserv es the right to make changes to the product(s) and/ or information contained herei n w i thout notice. no liab ility is assumed as a result of their use or app lication. no rights under any patent accompany t he sale of any such product(s) or information.
TFS125H.doc v e rsion 1.2 18.06.2003 vi telefilter filter specification tfs 125 h 3/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m stability characteristics after the follow i ng tests the filter shall meet the w hole specification: 1. shock: 500g, 18 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5g respective ly , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow ): reflow possible: tw ice max.; for temperature conditions refer to the atta ched "air reflow temper ature conditions" on page 4; packin g tape & reel: iec 286 - 3, w i th exception of value for n and minimum bending radius; tape ty pe ii , embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters per reel: 3000 reel of empty components at start: min 300 mm reel of empty components at start including leader: min 500 mm trailer min 300 mm d o p o e f w p 1 em bo s s ed c a r r i e r t a p e co ve r t a p e g p 2 b o a o d 1 t a p e ( a ll d i m e n s io n s in m m ) w : 1 6 0, 3 po : 4 0, 1 d o : 1 , 5 + 0 , 1 e : 1 , 75 0 , 1 f : 7, 5 0, 1 g (m i n ) : 0 , 6 0 p 2 : 2 0 , 1 p 1 : 8 0 , 1 d 1 ( m i n ) : 1, 5 a o : 5, 3 0 0, 1 b o : 9, 7 0 0, 1 ct c t : 1 3 , 5 0, 1 r eel (all dim e nsions in m m ): a : 330 w 1 : 16, 4 + 2 w 2 (m ax) : 22, 4 n (m in) : 50 c : 13, 0 + 0, 5 / - 0, 2 w 1 w 2 n c a the minimum bending radius is 45 mm. the m ounting surface of the filters faces the bottom side of the embossed carrier tape. markings on the filters can be read if the upper side of the carrier tape is regarded w i th the sprocket holes on its right. vi telefilter reserv es the right to make changes to the product(s) and/ or information contained herei n w i thout notice. no liab ility is assumed as a result of their use or app lication. no rights under any patent accompany t he sale of any such product(s) or information.
TFS125H.doc v e rsion 1.2 18.06.2003 vi telefilter filter specification tfs 125 h 4/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m a i r re flow te mpe r a t ure c onditions 1st and 2nd air ref l ow prof ile name: pre-heat ing periods main-heat ing periods peak t e mperat ure t e mp eratu r e: 150 c - 170 c over 200 c 255 c 5 c t i m e : 60 sec. - 90 sec. 20 sec. - 25 sec. c h i p - m ount a i r re f l ow pr of i l e ti m e / s e c . t e mper at ur e / c 0 20 40 60 80 100 120 140 160 180 200 220 240 260 0 2 0 4 0 6 0 8 0 100 120 140 160 180 200 220 240 t able f o r t e mperat ure vs. t i me during t he air ref l ow process t o lerance of t e mperat ures: 5 c t i me / sec. t e mperat ure / c t i me / sec. t e mperat ure / c 0 23 140 160 10 34 150 161 20 46 160 164 30 60 170 170 40 80 180 180 50 103 190 205 60 121 195 230 70 134 200 255 80 143 205 230 90 150 210 205 100 154 215 180 110 156 220 165 120 158 230 140 130 159 240 120 vi telefilter reserv es the right to make changes to the product(s) and/ or information contained herei n w i thout notice. no liab ility is assumed as a result of their use or app lication. no rights under any patent accompany t he sale of any such product(s) or information.
TFS125H.doc v e rsion 1.2 18.06.2003 vi telefilter filter specification tfs 125 h 5/5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m history version reason of changes name date dev e lopment specification 1.0 generation of development s pecification pfeiffer 2 4 . 0 1 . 2 0 0 3 1.1 ty pical values and termi nating impedance added pfeiffer 24.04.2003 1.2 absolute group delay and inband mask changed accordi ng customer specification pfeiffer 18.06.2003 versions 1.0.4 and 2.0.0 vi telefilter reserv es the right to make changes to the product(s) and/ or information contained herei n w i thout notice. no liab ility is assumed as a result of their use or app lication. no rights under any patent accompany t he sale of any such product(s) or information.
|
