View IFC165PQ40_8623943.PDF datasheet online --- IC-ON-LINE

Datasheet File OCR Text:

ifc165 series 165 watt force cooled (12 cfm) small size 3.0?x 5.0?x 1.25 built-in oring diodes (single o/p models) wide operating temperature -25 ? to +70 ? level b conducted emissions en61000-3-2, 3 compliant universal ac input 90-264 vac input frequency 47-63 hz 1-4 outputs mating connector & loom kits available the ifc165 series of multi output ac-dc, 165 watt power supplies from xp has outputs from 5 vdc to 48 vdc, with single output models offering a 12 v 1a fan supply. these high density power supplies are available with dual, triple and quad outputs and meet en55022 level b emi/emc specifications with external filter. ifc165 power supplies will deliver full power between -25 ? and +50 ? and up to +70 ? with derating and only 12 cfm of cooling. features include a built in oring diode on single output models. comprehensive overvoltage, overload and short circuit protection is built-in, with looms and connector kits available from stoc k.
input characteristics 2 xppower.com characteristic minimum typical maximum units notes & conditions input voltage - operating 90 264 vac input frequency 47 50/60 63 hz input current - no load 62 ma at 90 vac input current - full load 2.25 a at 90 vac inrush current 66 a 230 vac input protection ac line fuse earth leakage current <750 ? 240 vac, 50 hz all specifications are at nominal input, full resistive load at 25 ? unless otherwise stated. output characteristics characteristic minimum typical maximum units notes & conditions output voltage 5 48 vdc model-dependent initial set accuracy % see output tolerance output voltage adjustment n/a % not adjustable by user minimum load 5 w start up delay 1.5 15 ms see graph start up rise time 20 ms see graph hold up time 22 ms see graph output tolerance ? % 5 w min load on any combination of outputs required. figure quoted is total line, load and initial set accuracy transient response 5 % recovering to within 1% in 500 ? for 25% load change ripple & noise ? % overvoltage protection 113 125 145 % recycle input to reset overload protection 150 % vnom hiccup mode, auto-recovery control and signalling characteristic notes & conditions remote sense compensates for 0.5 v (output 1 only) ac ok see timing table power good see timing table reliability & service life characteristic typical units notes & conditions mtbf 200,000 hours calculated mean time between failures, per bellcore isolation characteristic minimum typical maximum units notes & conditions input to output test voltage 3000 vac test duration 1 minute input to ground test voltage 1500 vac test duration 1 minute output to ground test voltage 500 vac test duration 1 minute other specifications characteristic minimum typical maximum units notes & conditions weight 0.57 / 260 lb / g power density 8.8 w/in 3
xppower.com environmental requirements 3 characteristic minimum typical maximum units notes & conditions operating temperature -25 +70 ? derate linearly from 100% load at 50 ? to 50% load at 70 ? storage temperature -40 +85 ? cooling 12 cfm required for full power humidity 85 %rh non-condensing operating altitude 3000 m vibration 2.4 g 5-500 hz, 3 axis shock 15 g pk emc electromagnetic compatibility - immunity phenomenon standard test level criteria notes & conditions harmonic current en61000-3-2 a voltage flicker en61000-3-3 3 b eft en61000-4-4 3 b radiated field en61000-4-3 3 b surges en61000-4-5 3 b dips & interruptions en61000-4-11 30%, 10 ms 60%, 100 ms 100%, 500 ms a b b standards compliance list standard category en60950 en60950-2 : 2001 ul / cul 60950 ul60950 : 2003 1st edition iec60950 iec60950 : 2001 1st edition ce lv directive safety agency approvals standard file number ul / cul 60950 e137895 en60950 model numbers - outputs model number output 1 output 2 output 3 output 4 vnom imax vnom imax vnom imax vnom imax ifc165ps05 +5.0 v 33.0 a +12.0 v 1.0 a ifc165ps12 +12.0 v 13.7 a +12.0 v 1.0 a ifc165ps24 +24.0 v 6.9 a +12.0 v 1.0 a ifc165ps48 +48.0 v 3.4 a +12.0 v 1.0 a ifc165pt31 +5.0 v 21.0 a +12.0 v 6.0 a -12.0 v 1.0 a IFC165PQ40 +3.3 v 16.0 a +5.0 v 20.0 a +12.0 v 6.0 a -12.0 v 1.0 a emc electromagnetic compatibility - emmissions phenomenon standard test level criteria notes & conditions conducted en55022/en60601-1-2 a level b with external filter
xppower.com 4 derating curves - efficiency against output load efficiency against output load 115 vac input 0 10 20 30 40 50 60 70 80 90 012345678 output load (amps) efficiency % efficiency against output load 230 vac input 0 10 20 30 40 50 60 70 80 90 012345678 output load (amps) efficiency % 100 ifc165ps24 ifc165ps24
xppower.com 5 typical power up characteristics ifc165ps24 start up time 115 vac ifc165ps24 start up time 230 vac ifc165ps24 rise time 115 vac ifc165ps24 rise time 230 vac
xppower.com 6 typical transient response transient response - 75-100% load change (24 v model) transient response - 0-100% load change (24 v model) transient response - 100-0% load change (24 v model)
xppower.com 7 typical ripple & noise 24 v model capacitive load the power supply will power up and operate normally with capacitances listed below simultaneously present on the outputs. output capacitve load (f) pt31/ pq40 ps05 ps12 ps24 ps48 +3.3 v / +2.5 v 6000 ? +5 v 10000 ? 10000 ? +12 v 1000 ? 4000 ? -12 v aux 350 ? 350 ? 350 ? 350 ? 350 ? 15 v 24 v 2000 ? 48 v 500 ?
xppower.com signal timing 8 t1 95% 10% vac pwr good v1 t2 t3 t4 t6 t5 min max t1 200 ms 1.5 s t2 0.2 ms 20 ms t3 100 ms 500 ms t4 -- <50 ? t5 >20 ms -- t6 >2 ms -- power good signal / ps_ok signal the power good signal provides a high logic level to indicate that sufficient time has expired for the dc outputs to be within their reg- ulation limits and that sufficient mains energy is stored by the power supply to ensure continuous power operation within speci fication for the duration of the hold-up time. when the ac mains power is removed for a period longer than 20ms, the power good signal transitions to a low logic level. the ps_ok signal is the logical complement of the power good signal and both signals are +5v dc ttl-compatible on all units, with the exception of IFC165PQ40 and ifc165pt31 which have an open-collector output requiring a pull-up resistor for ttl compatiblility. the electrical specifications for the power good and ps_ok outputs are described below: signal type +5 vdc, ttl compatible low logic level <0.4 v when sinking 4 ma high logic level open collector output (see next) power good pull-up resistor ttl compatible only on pt31 and pq40 models power on delay between 100 and 500 ms after v1 outputs reaches regulation power down warning >2 ms before v1 reaches minimum regulated output rise time <50 ? from 10% to 90% point ps_ok logical complement of power good signal. open collector output without a pull-up resistor
xppower.com 9 hold up time 115 vac 230 vac
xppower.com 10 emc plots ifc165ps12 model ifc165ps12 model en55022 level a en55022 level b recommended filters for en55022 level b ifc 165 model number iec inlet filter chassis mount filter ifc165ps05 fn9222r-3/06 fn2010-3/06 ifc165ps12 fn9222r-3/06 fn2010-3/06 ifc165ps24 fn9222r-3/06 fn2010-3/06 ifc165ps48 fn9222r-3/06 fn2010-3/06 ifc165pt31 fn321-3/05 fn2020-3/06 ifc165pt40 fn321-3/05 fn2020-3/06
xppower.com 11 mechanical drawings 3.00 (76.2) 2.55 (64.8) 5.00 (127.0) 4.55 (115.5) pin 1 j2 j3 0.16 (4 places) safety ground connection point pin 1 j1 top pin 1 j4 terminal 1 led 1.00 (25.4) 1.25 31.75) 0.19 (4.83) 0.06 (1.52) side hardware shown for reference only - not included end ifc165ps05 model 3.00 (76.2) 2.55 (64.8) 5.00 (127.0) 4.55 (115.5) pin 1 pin 1 pin 1 j2 j3 j4 0.16 (4 places) safety ground connection point pin 1 j1 top end ifc165ps12/24/48 models 1.00 (25.4) 1.25 31.75) 0.19 (4.83) 0.06 (1.52) side hardware shown for reference only - not included 1. all dimensions in inches (mm). 2. weight 0.57 lb (260 g) approx. 3. the maximum width for the screw head is 0.28 (7.1). 4. #6 or m3 screws recommended. 5. 0.25 inch hex or round stand-offs recommended. 1. all dimensions in inches (mm). 2. weight 0.57 lb (260 g) approx. 3. the maximum width for the screw head is 0.28 (7.1) 4. #6 or m3 screws recommended. 5. 0.25 inch hex or round stand-offs recommended
xppower.com 12 mechanical drawings 3.00 (76.2) 2.55 (64.8) 5.00 (127.0) 4.55 (115.5) pin 1 j2 j3 0.16 (4 places) safety ground connection point pin 1 j1 top pin 1 end ifc165pt31/oq40 models 1.00 (25.4) 1.25 31.75) 0.19 (4.83) 0.06 (1.52) side hardware shown for reference only - not included conn pin connector pinouts ps05 ps12 ps24 ps48 pt31 pq40 j1 1 neutral neutral neutral neutral neutral neutral 2 3 line line line line line line j2 1 +5 vdc +12 v +24 v +48 v -12 v -12 v 2 +5 vdc +12 v +24 v +48 v +12 v +12 v 3 +5 vdc +12 v +24 v +48 v n/a +3.3 v 4 rtn rtn rtn rtn n/a +3.3 v 5 rtn rtn rtn rtn n/a +3.3 v 6 rtn rtn rtn rtn rtn rtn 7 rtn rtn 8 rtn rtn 9 rtn rtn 10 rtn rtn 11 +5 v +5 v 12 +5 v +5 v 13 +5 v +5 v 14 +5 v +5 v j3 1 n/c ac ok ac ok ac ok pg pg 2 p s ok pg pg pg n/a +3.3 v r s 3 pg c s c s c s -r s en s e -r s en s e 4 v1 s en s e+ +r s en s e +r s en s e +r s en s e 5 0v s en s e- -r s en s e -r s en s e -r s en s e 6 c s rtn rtn rtn j4 1 +12 v +12 v +12 v +12 v 2 rtn rtn rtn rtn conn mating connectors ps05 ps12/24/48 pt31 & pq40 j1 mating connector 09-50-8031 09-50-8031 09-50-8031 crimp pin s 08-52-0113 08-52-0113 08-52-0113 j2 mating connector terminal block 09-50-8061 09-50-8141 crimp pin s n/a 08-52-0113 08-52-0113 j3 mating connector 22-01-3057 22-01-3067 22-01-3037 crimp pin s 08-50-0114 08-50-0114 08-50-0114 j4 mating connector 22-01-3027 22-01-3027 n/a crimp pin s 08-50-0114 08-50-0114 n/a 1. all dimensions in inches (mm). 2. weight 0.57 lb (260 g) approx. 3. the maximum width for the screw head is 0.28 (7.1). 4. #6 or m3 screws recommended. 5. 0.25 inch hex or round stand-offs recommended.
xppower.com 13 notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
atlanta . . . . . . . . . . .(678) 474-0268 austin . . . . . . . . . . .(512) 248-1140 chicago . . . . . . . . . .(630) 980-9890 colorado . . . . . . . . .(720) 279-2449 connecticut . . . . . . .(860) 633-0717 dallas . . . . . . . . . . . .(972) 578-1530 new england . . . . . .(603) 894-4420 new jersey . . . . . . .(973) 658-8001 northern california . .(408) 732-7777 north carolina . . . . .(919) 834-8050 ohio . . . . . . . . . . . . .(614) 433-9140 orange county . . . .(714) 712-4504 pacific northwest . . .(425) 488-5821 pennsylvania . . . . . .(484) 875-3131 rochester, n.y . . . . .(585) 272-0250 san diego . . . . . . . .(760) 597-2100 toronto . . . . . . . . . .(905) 278-1060 vancouver, bc . . . . .(604) 469-8782 wisconsin . . . . . . . .(262) 743-1444 belgium . . . . . . . . .+31 183 645000 denmark . . . . . . . . . . . .43 42 38 33 france . . . . . . . . . . . .0820 801 401 germany . . . . . . . . . .0421 63933-0 netherlands . . . . . . . .0183 645000 norway . . . . . . . . . . . . .63 89 49 20 sweden . . . . . . . . . .08 555 367 00 switzerland . . . . . . . .056 483 34 00 united kingdom . . . .0118 984 5515 austria . . . . . . . . . . . .022 823 1440 vitecom czech republic . . . . . .235 366 129 vums finland . . . . . . . . . . . .09 2906 1990 cool power israel . . . . . . . . . . . . . .09 741 7277 tritech italy . . . . . . . . . . . . . .039 2876 027 mieltec poland . . . . . . . . . . .0 22 8178 022 euro elektronica portugal . . . . . . . .+351 21 8484542 digicontrole russia . . . . . . . . . . . . .952 340 636 prosoft south africa . . . . . . . .011 453 1910 vepac turkey . . . . . . . . . . .0 312 417 0716 bupat xp power 990 benecia avenue sunnyvale, ca 94085 phone : +1 408 732-7777 fax : +1 408 732-2002 email : nasales@xppower.com north american s ales offices european s ales offices distributors north american hq xp power horseshoe park pangbourne berkshire, rg8 7jw phone : +44 (0)118 984 5515 fax : +44 (0)118 984 3423 email : eusales@xppower.com european hq xp power 629 aljunied road #04-08 cititech industrial building 389838 singapore phone : +65 68469368 fax : +65 67418730 email : apsales@xppower.com asian hq www.xppower.com 10-aug-05 www.xppower.com

▲Up To Search▲

Price & Availability of IFC165PQ40

	To Download IFC165PQ40 Datasheet File
If you can't view the Datasheet, Please click here to try to view without PDF Reader .